HS code-based supply risk mitigation

Engine cleaning sludge: solve the sludge problem and HS code-based supply risk mitigationclean it easily! With the increasing use time of cars, the problem of oil sludge is becoming more and more common. Oil sludge mainly refers to the carbon accumulation, sediment and other impurities generated inside the engine. These substances will be attached to various parts of the engine. If it is serious, it will hinder the normal operation of the engine and even cause damage to the engine. Routine measures such as replacing the oil filter and adding oil cleaner cannot completely solve the problem. Therefore, many car owners can solve this problem by cleaning the engine sludge in daily maintenance, which can not only extend the life of the engine, but also improve the performance and safety of the car. I. Why does the engine need to clean the oil sludge?The long-term use of cars will produce oil pollution and impurities, forming carbon accumulation and causing oil sludge problems that cannot be ignored. This problem will gradually penetrate into the entire engine and block the normal operation of certain parts, which will lead to poor performance of the engine. If it is not cleaned in time, it may cause the following problems: 1. The engine noise increases 2. The oil is cloudy and the color turns black 3. Slow acceleration of the engine 4. Oil filter element contamination 5. Engine stuck II. When does the engine need to be cleaned? 1. Often driving in congested urban traffic, vehicles that are often used at low speed, idling or parking for a long time. Two. Low-quality oil has been used for a long time, and the oil has not been replaced according to the regulations. 3. High-speed continuous vehicles, such as taxis and other long-distance high-speed vehicles, such as large trucks, etc.Four. Vehicles that frequently take short distances and stop in the middle, such as self-driving tours, carpooling, etc. III. There are usually two ways to clean engine sludge. One is to use simple and easy-to-use oil cleaners, and the other is to deeply clean the engine through professional equipment. 1. Oil cleaner: The use of special oil sludge cleaner for automobiles can quickly clean the engine. Such products can usually be found and purchased in stores. The specific methods are as follows: a. After the engine cools down, remove the oil and add detergent (in the proportion required in the product manual). After about 3-5 minutes, the engine will run for 2-3 minutes. B. Turn off the engine and wait for about 10 minutes to let the detergent evenly cover all parts of the engine. C. Discharge the detergent and sludge, add new oil and replace a new oil filter.D. Start the engine and run to about 50 kilometers to cycle the oil and oil cleaner. Finally, drain the engine oil and engine oil cleaner cleanly and add a new engine oil. 2. Professional cleaner: Engine cleaning can be carried out in professional places such as automobile repair shops and repair shops. The use of professional equipment can clean the oil sludge, carbon, sediment and other impurities inside the engine more thoroughly and effectively. The specific methods are as follows: a. Find professional and technical personnel who understand the condition of the vehicle to check the condition of the vehicle to ensure that the use of cleaning equipment can achieve the expected effect. B. After the engine cools down, start the cleaning equipment and let the equipment work in the appropriate mode and heat. If you use a water-based liquid, you need to start the engine first! C. High-pressure flushing inside the engine through the washer to clean oil sludge, carbon, sediment and other impurities.D. After completion, inspect the engine to see if the possible oil sludge in the wearing part has been cleaned. E. Replace the old parts such as the cleaned oil and oil filter, and add new oil and filter. IV. Precautions Because the engine needs to be cleaned, there will also be certain risks and precautions in the process: 1. Because the cleaning solution has chemical properties, in order to avoid damage to engine parts, it is recommended to choose professional and technical personnel to clean, and do not operate by yourself. Two. Don't wait until the engine problem is serious to clean the oil sludge, and maintain and clean the vehicle regularly. 3. After cleaning the engine, it is necessary to drain the oil and oil cleaner and replace the new oil and oil filter, otherwise it will cause more problems. Put togetherThe normal performance of the engine is crucial to the whole car, so it is very necessary to ensure the cleanliness and smoothness of the engine. If you haven't cleaned the engine sludge, now is the time to start. By cleaning the oil sludge, you can ensure that the car is always in the best performance and extend the service life of the car.

Contact Us
Phone：020-83484664