Trade data solutions for wholesalers

Engine cylinder maintenance cost overview The Trade data solutions for wholesalerscar engine is the "heart" of the whole vehicle, but with the increase of use time, some faults will inevitably appear. Among them, the problem of engine cylinder pulling is relatively common and also a relatively serious fault. So, how much does it cost to repair the engine cylinder? This article will give you a detailed list of engine cylinder maintenance costs. I. The reason why the engine pulls the cylinder means that the sealing between the cylinder and the cylinder head fails, resulting in the inability of gasoline and air to burn normally in the cylinder. There are many reasons, mainly the following points: 1. Changes in cylinder volume: After the engine is used for a period of time, the cylinder wall is worn or cautered.The volume of the cylinder becomes smaller and loses a good match with the piston, resulting in an abnormal compression ratio, which in turn causes the cylinder to pull the cylinder. Two. Piston wear: The most common wear of the engine piston is the wear of the piston ring, which will cause serious carbon accumulation in the cylinder. At the same time, it will also cause excessive friction of the cylinder and the piston ring during operation, causing it to produce too much heat, thus deforming the cylinder and causing the engine to pull the cylinder. 3. Failure of the cylinder head or gasket: The cylinder head needs to be eroded by high pressure during the working process, which causes the metal of different components to corrode and rust, causing the cylinder head to lose its original sealing performance, and also cause the engine to pull the cylinder. Four. Other problems: such as shock, overheating, fuel consumption and other problems are also easy to cause the engine to pull the cylinder. II. The harm of engine cylinder pulling seriously affects the normal operation of the car, resulting in different degrees of performance loss.For example: 1. Decrease in car power: Due to the abnormal pressure in the cylinder caused by pulling the cylinder, the fuel cannot burn normally, and the power of the car will be greatly affected, resulting in a decrease in the output power of the engine. Two. Increased fuel consumption: The engine pulls the cylinder leads to incomplete combustion of gasoline, which will lead to an increase in vehicle fuel consumption and increase the driver's cost of use. 3. Environmental protection emissions do not meet the standard: the engine cylinder pulls, resulting in incomplete combustion of gasoline, and the increase in harmful substances produced, which cannot be completely treated by ternary catalysts, which ultimately affects the emission standard. Four. Increase engine wear: Pulling the cylinder of the engine will cause excessive air pressure in the cylinder, causing impact on the mechanical parts of the engine, accelerating the wear of parts, and eventually leading to more mechanical problems. III. List of engine cylinder maintenance costs. If there is a cylinder failure in the engine, it must be dealt with in time.The cost of pulling the engine cylinder is to repair, not to replace it. The cost of replacing a new engine is high, which is unaffordable for most car owners. So, how much does it cost to repair the engine cylinder? 1. Maintenance labor cost Engine cylinder pulling involves removing the cylinder head and cleaning the piston head, valve and other parts, so it takes a certain amount of time. Therefore, maintenance labor costs are an important aspect of maintenance costs. Usually, the standard of maintenance hours ranges from 70 yuan to 200 yuan per hour. Two. The material cost of the engine is waterproof and sealed, and the choice of cylinder, piston ring, cylinder head and other accessories directly affects the service life and failure rate of the engine. Therefore, we must pay attention to quality and cost-effectiveness when buying parts. The price of specific accessories varies depending on the car brand and model. In general, the cost of basic parts and maintenance materials is about 1,000 yuan to 5,000 yuan.3. Other expenses may also occur during the maintenance period, such as cleaning and overhaul. The value of these expenses is relatively small and generally does not cause a great burden on the car owner. In a word, the maintenance cost of the engine cylinder may vary depending on the degree of failure, the model, the complexity of the maintenance route and other reasons, generally between 4,000 yuan and 10,000 yuan. IV. How to prevent the engine from pulling the cylinder? If your car has not had a cylinder failure, the following methods may help you prevent this failure: 1. There is a common saying in the maintenance of the oil regularly: if the oil is not replaced in time, the impurities precipitated by the oil will "feed back" the lubricating parts through the oil line, which will aggravate wear or directly cause the engine to pull the cylinder. Two. Regularly replace the air filter. The air filter plays a role in preventing dust, sand and other foreign matter from entering the engine. Failure to replace it for a long time will lead to insufficient fuel supply.3. Regular maintenance. Regular car maintenance can find problems with the car in time, repair them, and keep the car in the best condition at all times. Four. The original parts of the designated 4s store replacement of auto parts are relatively higher quality, stronger and more stable. If you plan to save more maintenance costs while saving the life of the car, then the original auto parts are the best choice. In a word, you can read the relevant articles in advance to learn more information and knowledge about the cost of cylinder maintenance of automobile engines. Since high-quality car maintenance requires a certain amount of cost support, car owners should not ignore this aspect. It is very necessary to understand the car maintenance problem in advance.

Contact Us
Phone：020-83484664